Alaska Airlines Flight 261, a McDonnell Douglas MD-83 aircraft, experienced a fatal accident on January 31, 2000 at the Pacific Ocean about 2.7 miles (4.3km) north of Anacapa Island, California. The two pilots, three cabin crewmembers, and 83 passengers on board were killed and the aircraft was destroyed. It was the highest ever death toll of any aviation accident involving a McDonnell Douglas MD-83. Alaska 261 was a scheduled international passenger flight from Lic. Gustavo Díaz Ordaz International Airport in Puerto Vallarta, Mexico, to Seattle-Tacoma International Airport in Seattle, Washington, with an intermediate stop planned at San Francisco International Airport in San Francisco, California.
The subsequent investigation by the National Transportation Safety Board determined that inadequate maintenance led to excessive wear and catastrophic failure of a critical flight control system during flight. The probable cause was stated to be "a loss of airplane pitch control resulting from the in-flight failure of the horizontal stabilizer trim system jackscrew assembly's acme nut threads. The thread failure was caused by excessive wear resulting from Alaska Airlines's insufficient lubrication of the jackscrew assembly."
The aircraft, manufactured in 1992, had over 26,000 hours of flight before the crash.
50 people on board the plane were bound for Seattle. They were 47 passengers and the three crew members. Of the remaining 36 passengers and the remaining two crew members, most of them were headed for San Francisco. Of the passengers, 1 was Mexican and 1 was British; the rest were US citizens.
Of the occupants, at least 35, including 12 employees, were connected to Alaska Airlines or Horizon Air in some manner, leading many airline employees to mourn for the losses in the crash. Alaska Airlines stated that, during slower traveling days, it was common for employees to fill seats that would have otherwise been empty. Bouquets of flowers started arriving at the company's headquarters in SeaTac, Washington the day after the crash occurred.
- Jean Gandesbery, author of Seven Mile Lake, died with her husband Robert Gandesbery
- Morris Thompson, Commissioner of the Bureau of Indian Affairs from 1973 to 1976, died with his wife Thelma and daughter Sheryl.
- Tom Stockley, wine columnist for The Seattle Times.
- Cynthia Oti, a financial talk show host at San Francisco's KSFO-AM.
Initial flight segmentEdit
Alaska 261 departed from Puerto Vallarta at 1:37 p.m. PST, and climbed to its intended cruising altitude of flight level 310 (31,000ft). Approximately 2 hours into the flight, the flight crew, consisting of captain Ted Thompson, 53 and first officer William "Bill" Tansky, 57, first contacted the airline's dispatch and maintenance control facilities in SeaTac, Washington, and on a shared company radio with operations and maintenance facilities at Los Angeles International Airport (LAX) discussed a jammed horizontal stabilizer and a possible diversion to LAX. The jammed stabilizer prevented operation of the trim system, which normally would make slight adjustments to the flight control surfaces to keep the plane stable in flight. At their cruising altitude and speed the position of the jammed stabilizer required the pilots to pull on their controls with approximately 10 pounds (44N) of force to keep level. Neither the flight crew, nor company maintenance, were able to determine the cause of the jam. Repeated attempts to overcome the jam with the primary and alternate trim systems were unsuccessful
During this time the flight crew had several discussions with the company dispatcher about whether to divert to Los Angeles, or continue on as planned to San Francisco. Ultimately the pilots chose to divert. Later the NTSB found that while "the flight crew's decision to divert the flight to Los Angeles...was prudent and appropriate", nonetheless "Alaska Airlines dispatch personnel appear to have attempted to influence the flight crew to continue to San Francisco...instead of diverting to Los Angeles." Cockpit Voice Recorder (CVR) transcripts indicate that the dispatcher was concerned about the effect on the schedule ("flow") should the flight divert.
First dive and recoveryEdit
At 4:09 p.m., the flight crew was able to unjam the horizontal stabilizer with the primary trim system, however, upon being freed, it quickly moved to an extreme "nose-down" position, forcing the aircraft into a dive. Alaska 261 went from about 31,500 feet to between 23,000 and 24,000 feet in around 80 seconds. Both pilots struggled together to regain control of the aircraft, and only by exerting a pulling force of 130 to 140 pounds (59.1 to 63.6kg) on the controls were the flight crew able to arrest the 6,000 foot-per minute descent of the aircraft and stabilize themselves at approximately 24,400 feet.
Alaska 261 informed air traffic control (ATC) of their control problems. After the flight crew stated their intention to land at LAX, ATC enquired if they wanted to proceed to a lower altitude in preparation for approach. The captain replied: "I need to get down to about ten, change my configuration, make sure I can control the jet and I'd like to do that out here over the bay if I may." Later, during the public hearings into the accident, the request by the pilot not to overfly populated areas was specifically commended by NTSB board members. During this time the flight crew considered, and rejected, any further attempts to correct the runaway trim. They proceeded to descend to a lower altitude and started to configure the aircraft for landing at LAX.
Second dive and crashEdit
Beginning at 4:19 p.m., the CVR recorded the sounds of at least four distinct "thumps", followed 17 seconds later by an "extremely loud noise". The aircraft rapidly pitched over into a dive. Several aircraft in the vicinity had been alerted by ATC to maintain visual contact with the stricken jet and they immediately contacted the controller. One pilot radioed "that plane has just started to do a big huge plunge"; another reported, "Yes sir, ah, I concur he is, uh, definitely in a nose down, uh, position descending quite rapidly." ATC then tried to contact Alaska 261. The crew of a Skywest airliner reported "He's, uh, definitely out of control"  Although the CVR captured the co-pilot saying "Mayday", no radio communications were received from the flight crew during the final event.
The CVR transcript reveals the pilots' continuous attempts for the duration of the dive to regain control of the aircraft. At one point, unable to raise the nose, they attempted to fly the aircraft "upside-down". However the aircraft was beyond recovery; it descended inverted and nose-down about 18,000 feet in 81 seconds, a descent rate exceeding 13,300 feet per minute, before hitting the ocean at high speed. At this time, pilots from aircraft flying in the same area reported in, with one SkyWest Airlines pilot saying, "and he's just hit the water," meaning the plane had crashed into the ocean. Another reported, "Yeah sir, he, uh, he, uh, hit the water, he's, uh, down." Everyone on board died when the plane struck the water, and the aircraft was destroyed upon impact.
Wreckage recovery and analysisEdit
Using side-scan sonar, remotely operated vehicles, and a commercial fishing trawler, workers recovered about 85% of the fuselage (including the tail section) and a majority of the wings. In addition, both engines, as well as the Flight Data Recorder (FDR) and CVR were retrieved. All wreckage was unloaded at Port Hueneme, California for examination and documentation. Both the horizontal stabilizer trim system jackscrew (also referred to as "acme screw"), and the corresponding acme nut, which the jackscrew turns through, were retrieved. As the jackscrew rotates it moves up or down through the (fixed) acme nut. This up and down motion moves the horizontal stabilizer for the trim system. The jackscrew was found with metallic filaments wrapped around it; these were later determined to be remnants of the threads from the acme nut.
Later analysis estimated that 90% of the threads in the acme nut had been previously worn away, and that they were then completely sheared off during the accident flight. Once the threads failed, the horizontal stabilizer assembly was then subject to aerodynamic forces that it could not withstand, and ultimately failed. Based on the time since the last inspection of the jackscrew assembly, the NTSB determined that the wear had occurred at a much faster than average rate (0.012inch per 1,000 flight hours, when the expected wear was 0.001inch per 1,000 flight hours). The NTSB considered a number of potential reasons for this excessive wear, including the substitution by Alaska Airlines (with the approval of the aircraft manufacturer Boeing) of Aeroshell 33 grease instead of the previously approved lubricant, Mobilgrease 28. The use of Aeroshell 33 was found not to be a factor in this accident. Insufficient lubrication of the components was also considered as a reason for the wear. Examination of the jackscrew and acme nut revealed that no effective lubrication was present on these components at the time of the accident. Ultimately, the lack of lubrication and resultant excessive wear of the acme nut threads were determined to be the direct causes of the accident.
Identification of passengersEdit
Crash victims were identified using fingerprints, dental records, tattoos, personal items, and anthropological examinations.
Inadequate lubrication and end play checksEdit
The investigation then proceeded to examine why scheduled maintenance had failed to adequately lubricate the jackscrew assembly. In interviews with the Alaska Airlines SFO mechanic who last performed the lubrication it was revealed that the task took about 1 hour, whereas the aircraft manufacturer estimated the task should take 4 hours. This and other evidence suggested to the NTSB that "the SFO mechanic who was responsible for lubricating the jackscrew assembly in September 1999 did not adequately perform the task." Laboratory tests indicated that the excessive wear of jackscrew assembly could not have accumulated in just the 4 months period between the September 1999 maintenance and the accident flight. Therefore, the NTSB concluded that "more than just the last lubrication was missed or inadequately performed."
In order to monitor wear on the jackscrew assembly a periodic maintenance inspection called an "end play check" was used. The NTSB examined why the last end play check on the accident aircraft in September 1997 did not uncover excessive wear. The investigation found that Alaska Airlines had fabricated tools to be used in the end play check that did not meet the manufacturer's requirements. Testing revealed that the non-standard tools ("restraining fixtures") used by Alaska Airlines could result in inaccurate measurements, and that it was possible that if accurate measurements had been obtained at the time of the last inspection, these measurements would have indicated the excessive wear and the need for the replacement of the affected components.
Extension of maintenance intervalsEdit
Between 1985 and 1996 Alaska Airlines progressively increased the period in between jackscrew lubrication as well as end play checks with the approval of the Federal Aviation Administration (FAA). Since each lubrication or end play check subsequently not conducted had represented an opportunity to adequately lubricate the jackscrew or detect excessive wear, the NTSB examined the justification of these extensions. In the case of extended lubrication intervals, the investigation was not able to determine what information, if any, was presented by Alaska Airlines to the FAA prior to 1996. Testimony from an FAA inspector regarding an extension granted in 1996 was that Alaska Airlines submitted documentation from Boeing as justification for their extension.
End play checks were conducted during a periodic comprehensive airframe overhaul process called a "C-check". Testimony from the director of reliability and maintenance programs of Alaska Airlines was that a data analysis package based on the maintenance history of five sample aircraft was submitted to the FAA to justify the extended period between C-checks. Individual maintenance tasks (such as the end play check) were not separately considered in this extension. The NTSB found that "Alaska Airlines' end play check interval extension should have been, but was not, supported by adequate technical data to demonstrate that the extension would not present a potential hazard."
A special inspection conducted by the NTSB in April 2000 of Alaska Airlines uncovered widespread significant deficiencies that "the FAA should have uncovered earlier." The investigation concluded that "FAA surveillance of Alaska Airlines had been deficient for at least several years." The NTSB noted that in July 2001, an FAA panel determined that Alaska Airlines had corrected the previously identified deficiencies. However several factors led the Board to question "the depth and effectiveness of Alaska Airlines corrective actions" and "the overall adequacy of Alaska Airlines' maintenance program."
Systematic problems were identified by the investigation in the FAA's oversight of maintenance programs, including inadequate staffing, its approval process of maintenance interval extensions, and the aircraft certification requirements.
Aircraft design and certification issuesEdit
The jackscrew assembly was designed with two independent threads, each of which was strong enough to withstand the forces placed on it. Maintenance procedures such as lubrication and end play checks were to catch any excessive wear before it progressed to a point of failure of the system. The aircraft designers assumed that at least one set of threads would always be present to carry the loads placed on it, therefore the effects of catastrophic failure of this system were not considered, and no "fail-safe" provisions were needed.
In order for this design component to be approved ("certified") by the FAA without any fail-safe provision, a failure had to be considered "extremely improbable". This was defined as "having a probability on the order of 1 x 10-9 or less each flight hour." However the accident showed that certain wear mechanisms could affect both sets of threads, and that the wear might not be detected. The NTSB determined that the design of "the horizontal stabilizer jackscrew assembly did not account for the loss of the acme nut threads as a catastrophic single-point failure mode."
Jackscrew design improvementEdit
In 2001, NASA recognized the risk to its hardware (such as the Space Shuttle) attendant upon use of similar jackscrews. An engineering fix developed by engineers of NASA and United Space Alliance promises to make progressive failures easy to see and thus complete failures of a jackscrew less likely.
In addition to the probable cause, the NTSB found the following contributing factors:
- Alaska Airlines' extension of its lubrication interval for its McDonnell Douglas MD-80 horizontal stabilizer components, and the FAA's approval of that extension, the last of which was based on Boeing's extension of the recommended lubrication interval increased the likelihood that a missed or inadequate lubrication would result in excessive wear of jackscrew assembly acme nut threads and, therefore, was a direct cause of the excessive wear and contributed to the Alaska Airlines flight 261 accident.
- Alaska Airlines's extended end play check interval and the FAA's approval of that extension, which allowed the excessive wear of the acme nut threads to progress to failure without the opportunity for detection
- The absence on the McDonnell Douglas MD-80 of a fail-safe mechanism to prevent the catastrophic effects of total acme nut loss
During the course of the investigation, and later in its final report, the NTSB issued a total of 24 safety recommendations, covering maintenance, regulatory oversight, and aircraft design issues. More than half of these were directly related to jackscrew lubrication and end play measurement. Also included was a recommendation that pilots were to be instructed that in the event of a flight control system malfunction they should not attempt corrective procedures beyond those specified in the checklist procedures, and in particular in the event of a horizontal stabilizer trim control system malfunction the primary and alternate trim motors should not be activated, and if unable to correct the problem through the checklists they should land at the nearest suitable airport.
In NTSB board member John J. Goglia's statement for the final report, which was concurred with by all three other board members, he wrote:
After the crash occurred, Alaska Airlines management said that it hoped to handle the aftermath in a manner similar to that done by Swissair after the Swissair Flight 111 accident, as opposed to the manner that TWA handled the aftermath of TWA Flight 800; in other words, to provide timely information and compassion to the families of victims.
The families of the victims approved the construction of a memorial sundial that was placed at Port Hueneme. The sundial was designed by Santa Barbara artist Bud Bottoms to cast a shadow on a memorial plaque at 4:22 p.m. each January 31.
For their actions during the emergency, Captain Ted Thompson and First Officer Bill Tansky were awarded the Airline Pilots Association Gold Medal for Heroism, the only time the award has been given posthumously.
Both Boeing and Alaska Airlines eventually conceded liability for the crash, and all but one of the lawsuits brought by surviving family members were settled out-of-court before going to trial. Candy Hatcher of the Seattle Post-Intelligencer said "Many lost faith in Alaska Airlines, a homegrown company that had taken pride in its safety record and billed itself as a family airline."
Two victims from Alaska 261 were falsely named in paternity suits as the fathers of children in Guatemala in an attempt to gain insurance and settlement money. DNA testing revealed these claims to be false.
This crash was featured in a 2004 episode of Discovery Channel (Canada)'s Mayday television program (also known as Air Crash Investigation and also known as Air Emergency), titled Cutting Corners or Fatal Error.
The Ted Thompson/Bill Tansky Scholarship Fund was named after the two cockpit flight crew members.
Many residents of the City of Seattle had been affected by the disaster. As part of a memorial vigil in the year 2000, a column of light was beamed from the top of the Space Needle. Students and faculty at the John Hay Elementary School in Queen Anne, Seattle held a memorial for four Hay students who died in the crash. In April, 2001, John Hay Elementary dedicated the "John Hay Pathway Garden" which stands as a permanent living memorial to these students and their families. The City of Seattle public park Soundview Terrace was renovated in honor of the 4 Pearson and the 6 Clemetson family members, all Flight 261 victims from the same Seattle neighborhood of Queen Anne. The park's playground was named "Rachel's Playground" in honor of 6 year old Rachel Pearson who lived nearby and often played at the park.
The Alaska Airlines flight 261 crash has appeared in various advance fee fraud ("419") email scams. In these scams, a scammer uses the name of someone who died in the crash to lure unsuspecting victims into sending money to the scammer by claiming the crash victim left huge amounts of unclaimed money in a foreign bank account. The names of Morris Thompson and Ronald and Joyce Lake were used in schemes unrelated to them.
As of November 2011, Flight 261 no longer exists. The flight route designation for this route is now Flight 221. Alaska Airlines continues to operate the Puerto Vallarta-San Francisco-Seattle/Tacoma route; the airline also operates the Puerto Vallarta-Seattle/Tacoma route nonstop as Flight 203. The airline also retired all of its MD-80s in 2008 and now operates all Boeing 737 aircraft.
- ↑ 1.0 1.1 NTSB Abstract AAR-02/01
- ↑ "Alaska Airlines Flight 261: Searchers Hold Out Hope for Possible Survivors; Crash Takes Heavy Toll on Airlines Employees' Families." CNN International. February 1, 2000. Retrieved on February 16, 2010. "This is 1995 video of the plane. The MD-83 was manufactured in 1992 and had more than 26,000 of hours in flight."
- ↑ "HistoryLink Essay: Alaska Flight 261 bound for Seattle crashes into the Pacific Ocean on 31 January 2000." HistoryLink. Retrieved on May 31, 2009.
- ↑ "Flight 261 Special Report."Alaska Airlines. February 12, 2001. Retrieved on May 31, 2009.
- ↑ 5.0 5.1 Hatcher, Candy. "The anger and the grief linger one year later." Seattle Post-Intelligencer. Wednesday January 31, 2001. Retrieved on November 23, 2009.
- ↑ 6.0 6.1 Verhovek, Sam Howe. "Fate Leads An Airline To Grieve For Itself." The New York Times. February 2, 2000. Retrieved on November 23, 2009.
- ↑ Holmes, Stanley and Jeff Leeds. "THE CRASH OF FLIGHT 261; For Airline, Loss Feels Like Deaths in Family." Los Angeles Times. February 20, 2000. A23. Retrieved on December 14, 2009.
- ↑ "Seven Mile Lake (Hardcover)." Amazon.com. Accessed 31 October 2008.
- ↑ "Names of those aboard Alaska Airlines Flight 261." CNN. February 4, 2000. Retrieved on December 17, 2009.
- ↑ 10.0 10.1 10.2 10.3 "The Lives That Were Lost." CBS News. 2000. Retrieved on November 23, 2009.
- ↑ 11.00 11.01 11.02 11.03 11.04 11.05 11.06 11.07 11.08 11.09 11.10 11.11 11.12 11.13 11.14 11.15 11.16 11.17 11.18 11.19 11.20 11.21 11.22 11.23 11.24 11.25 11.26 11.27 11.28 11.29 11.30 11.31 11.32 11.33 11.34 11.35 11.36 11.37 11.38 Loss of Control and Impact with Pacific Ocean Alaska Airlines Flight 261
- ↑ 12.0 12.1 12.2 12.3 12.4 12.5 National Transportation Safety Board
- ↑ NTSB Board Meeting Transcript 12/10/2002 - Alaska Airlines 261
- ↑ 14.0 14.1 14.2 14.3 Aviation Safety Network > Accident investigation > CVR / FDR > Transcripts > Alaska Airlines Flight 261 - 31 JAN 2000
- ↑ "Alaska Airlines maintenance records raise new questions." CNN. February 14, 2000. Retrieved on September 28, 2009.
- ↑ The FailSafe Jackscrew Design
- ↑ Song, Kyung M. "Alaska Airlines copes with 'saddest, most tragic day'." The Seattle Times. Wednesday February 2, 2000. Retrieved on December 17, 2009.
- ↑ Denn, Rebekah. "Memorials quieter today, but Flight 261 grief still hurts." Seattle Post-Intelligencer. Thursday January 31, 2002. Retrieved on February 23, 2009.
- ↑ Porterfield, Elaine and Hector Castro. "Pilots honored for heroism during crisis." Seattle Post-Intelligencer. Thursday February 1, 2001. Retrieved on February 23, 2009.
- ↑ Kravets, David. "All but one suit settled in Flight 261 crash." Associated Press at Seattle Post-Intelligencer. Friday July 4, 2003. Retrieved on December 17, 2009.
- ↑ Hatcher, Candy. "Quest for truth proves lawyer's integrity." Seattle Post-Intelligencer. Wednesday August 22, 2001. Retrieved on February 23, 2009.
- ↑ "Ted Thompson/Bill Tansky Scholarship Fund." Alaska Airlines. Retrieved on February 23, 2009.
- ↑ Jamieson, Robert L. "Seattle still struggling to make sense of the Flight 261 tragedy." Seattle Post-Intelligencer. Tuesday February 8, 2000. Retrieved on November 23, 2009.
- ↑ Harrell, Debera Carlton. "Hay school family' remembers its own." Seattle Post-Intelligencer. Friday February 11, 2001. Retrieved on December 17, 2009.
- ↑ Official John Hay Elementary Web Site. "." Retrieved on November 15, 2010.
- ↑ Denn, Rebekah. "A park from Rachel, with love." Seattle Post-Intelligencer. Wednesday January 31, 2001.
- ↑ "Nigerian Advance Fee Scam Customized for Alaska: Morris Thompson variation could be taste of ploys to come." State of Alaska Department of Law. December 13, 2005. Retrieved on February 23, 2009.
- ↑ Le, Phuong Cat. "Latest e-mail uses Alaska Airlines crash victims to scam." Seattle Post-Intelligencer. November 9, 2007. Retrieved on February 23, 2009.
- Archive of Alaska Airlines news reports about 261
- Main NTSB Alaska Airlines Flight 261 investigation page
- The NTSB's full report
- Families of Alaska Airlines Flight 261
- "Navy expands search for debris at Alaska Airlines Flight 261 crash scene," United States Navy
- Applying Lessons Learned from Accidents, Alaska Airlines Flight 261 - Informative analysis at faa.gov, with technical diagrams and photos
- Seattle Post-Intelligencer special report